Toyota Avalon (XX50) 2019-2022 Service & Repair Manual: Removal

Toyota Avalon (XX50) 2019-2022 Service & Repair Manual / Vehicle Exterior / Exterior Panels / Trim / Grille Shutter / Removal

REMOVAL

CAUTION / NOTICE / HINT

The necessary procedures (adjustment, calibration, initialization, or registration) that must be performed after parts are removed and installed, or replaced during grille shutter removal/installation are shown below.

Necessary Procedure After Parts Removed/Installed/Replaced

Replaced Part or Performed Procedure	Necessary Procedure	Effect/Inoperative Function when Necessary Procedure not Performed	Link
*: Applies only for when removing and installing or replacing the television camera assembly.
Front television camera assembly, front bumper assembly or radiator grille	Television camera view adjustment Television camera assembly optical axis adjustment (Back camera position setting)*	Panoramic View Monitor System	for Initialization for Calibration
Front bumper assembly	Measurement of ultrasonic sensor detection angle Ultrasonic sensor detection angle registration	Intelligent Clearance Sonar System Intuitive Parking Assist System
Swing grill actuator assembly Radiator shutter sub-assembly	Change grille shutter control mode and/or perform initialization	Grille Shutter System

PROCEDURE

1. REMOVE FRONT BUMPER ASSEMBLY

Click here

2. REMOVE FRONT RADIATOR SIDE AIR GUIDE PLATE LH

(a) Disengage the 2 claws to remove the front radiator side air guide plate LH.

3. REMOVE FRONT RADIATOR SIDE AIR GUIDE PLATE RH

(a) Disengage the 2 claws to remove the front radiator side air guide plate RH.

4. REMOVE THERMISTOR ASSEMBLY

Click here

5. REMOVE RADIATOR SHUTTER SUB-ASSEMBLY

(a) Disconnect the connector.

(b) Disengage the clamp.

(d) Disengage the 2 guides to remove the radiator shutter sub-assembly as shown in the illustration.

Remove in this Direction

Reassembly

Luggage Compartment Door Outside Garnish

See More:

Toyota Avalon (XX50) 2019-2022 Service & Repair Manual > Front Seatback Heater: Components
COMPONENTS ILLUSTRATION *1 FRONT SEAT CUSHION SHIELD *2 FRONT SEAT FRONT CUSHION SHIELD *3 FRONT SEAT INNER CUSHION SHIELD - - ILLUSTRATION *1 SEPARATE TYPE FRONT SEATBACK ASSEMBLY *2 SEPARATE TYPE FRONT SEAT CUSHION ASSEMBLY Tightening torque for "Major areas involving basic vehicle performance suc ...

Toyota Avalon (XX50) 2019-2022 Service & Repair Manual: Removal

Reassembly

Luggage Compartment Door Outside Garnish

See More:

Toyota Avalon (XX50) 2019-2022 Owners Manual

Toyota Avalon (XX50) 2019-2022 Service & Repair Manual