Toyota Avalon (XX50) 2019-2022 Service & Repair Manual: A/C Switch Indicator does not Turn On

Toyota Avalon (XX50) 2019-2022 Service & Repair Manual / Vehicle Interior / Heating / Air Conditioning / Air Conditioning System(for Gasoline Model) / A/C Switch Indicator does not Turn On

DESCRIPTION

If none of the switch indicators on the air conditioning control panel (radio and display receiver assembly) illuminate, the following factors may be the cause.

Symptom

Factor

A/C switch indicator does not illuminate
  • Air conditioning amplifier assembly malfunction
  • Air conditioning control panel (radio and display receiver assembly) malfunction
  • A/C switch malfunction
  • A/C switch indicator malfunction (including when indicator turned off without switch operation)
  • Servo motor initialization (incomplete)
  • Mechanical locking of damper and damper link
  • Refrigerant pressure is extremely low
  • Low detected ambient temperature (including thermistor assembly malfunction)

PROCEDURE

1.

CHECK MALFUNCTION STATUS

(a) Check the malfunction status of switch indicators on the air conditioning control panel (radio and display receiver assembly).

Result

 Proceed to

Indicators are not always illuminated

A

Indicators are not illuminated only immediately after starting the engine

B
B

GO TO INITIALIZATION

A

2.

READ VALUE USING TECHSTREAM

(a) Connect the Techstream to the DLC3.

(b) Turn the engine switch on (IG).

(c) Turn the Techstream on.

(d) Enter the following menus: Body Electrical / Air Conditioner / Data List.

(e) Read the Data List according to the display on the Techstream.

Body Electrical > Air Conditioner > Data List

Tester Display

Measurement Item

Range

Normal Condition

Diagnostic Note

Ambient Temp Sensor

Thermistor assembly

Min.: -23.30°C (-9.94°F)

Max.: 65.95°C (150.71°F)

Actual ambient temperature displayed

Thermistor assembly circuit malfunction

  • When open circuit: -23.30°C (-9.94°F)
  • When short circuit: 65.95°C (150.71°F)
Body Electrical > Air Conditioner > Data List

Tester Display

Ambient Temp Sensor

OK:

The value displayed is 0°C (32°F) or higher.

OK

INSPECT REFRIGERANT PRESSURE WITH MANIFOLD GAUGE SET

NG

GO TO OTHER DIAGNOSIS PROCEDURE (Ambient Temperature Display System)

    Air Conditioning System(for Gasoline Model)

    Air Conditioning Compressor Magnetic Clutch Circuit

    See More:

    Toyota Avalon (XX50) 2019-2022 Service & Repair Manual > Lin Communication System(for Gasoline Model): Communication Malfunction between ECUs Connected by LIN (B2785)
    DESCRIPTION If the certification ECU (smart key ECU assembly) detects a communication error with an ECU connected to the certification bus lines for 7 seconds or more, DTC B2785 will be stored. DTC No. Detection Item DTC Detection Condition Trouble Area B2785 Communication Malfunction between ECUs C ...

    Toyota Avalon (XX50) 2019-2022 Owners Manual

    Toyota Avalon (XX50) 2019-2022 Service & Repair Manual

    © 2025 Copyright www.tavalon.net
    0.0115